2 layers139.9 × 85.8 mm
Pas hw
NGOQUOC98/ESP32_MODBUS_PCB_MASTER
This project was in development phase - we will remove this remark after release
198 parts1
4 layers114.3 × 86.4 mm
Linear window controller
eflukx/Linear-motor-window-controllerLinear quad/octa motor slide Window controller, featuring absolute position feedback control, motor current monitoring using a ESP32-S3 hi performance controller
- Size
- 114.3 × 86.4 mm
- Copper layers
- 4
- Thickness
- 1.6 mm
- Parts
- 201
- Nets
- 194
- Pads
- 1,018
- Tracks, vias
- 1,792, 431
- Pours
- 319
- Routed
- Yes
- KiCad
- KiCad 8.0 (file 20240108)
- Created
- 1 Feb 2024
- Updated
- 19 Aug 2024
Overview
Linear window controller is an open-source printed circuit board by eflukx, from the eflukx/Linear-motor-window-controller repository on GitHub. It is a 4-layer board of 114.3 × 86.4 mm with 201 parts on 194 nets, routed with 1,792 tracks and 431 vias.
It is built around the CP2102N-A01-GQFN24, ESP32-S3-WROOM-1-N16R2 and DRV8874PWP, with the TMP112AIDRLR(UMW), 93LC46BT-E/OT and DM9051NP among its other parts. Its parts include 63 resistors, 57 capacitors, 15 connectors, 14 ICs and 14 diodes. It belongs with the ESP32 boards of this library.
Main components
12
CP2102N-A01-GQFN24
QFN-24-EP(4x4)3Mbps 3V~3.6V Transceiver QFN-24-EP(4x4) USB Converters ROHSSilicon LabsUSB Converters
ESP32-S3-WROOM-1-N16R2
SMD,25.5x18mm-103.5dBm -40℃~+85℃ 2.4GHz 20.5dBm 355mA 3V~3.6V 95mA Bluetooth5.0 ESP32-S3 On-board PCB Antenna UART、SDIO、SPI、I2C、GPIO、PWM、ADC、I2S、JTAG、USB SMD,25.5x18mm WiFi Modules ROHSEspressif SystemsWiFi Modules
DRV8874PWP
HTSSOP-16-EP-40℃~+125℃ 1 200mΩ 750nA 9A Yes HTSSOP-16-EP Brushed DC Motor Drivers ROHSTexas InstrumentsBrushed DC Motor Drivers
TMP112AIDRLR(UMW)
SOT-563-50℃~+150℃ 1.4V~5.5V 10uA 12bit 26ms I2C、SMBus ±0.5℃ SOT-563 Temperature Sensors ROHSUMWTemperature Sensors
93LC46BT-E/OT
SOT-23-6-40℃~+125℃ 1,000,000 cycles 1Kbit 2.5V~5.5V 200 Years 2MHz 6ms Built-in write enable latch (WEL)、Power-down/Power-up protection circuit SPI SOT-23-6 EEPROM ROHSMicrochip TechnologyEEPROM
DM9051NP
QFN-32-EP(5x5)10BASE-T、100BASE-TX 16KB 3.135V~3.465V SPI SPI、MII Yes QFN-32-EP(5x5) Ethernet Controllers ROHSDAVICOMEthernet Controllers
LIS3DH
LGA-16(3x3)-40℃~+85℃ 1.71V~3.6V 16bit 500nA Accelerometer Motion event detection SPI、I2C X,Y,Z ±16g LGA-16(3x3) Accelerometers ROHSSTMicroelectronicsAccelerometers
PCA9555PW
TSSOP-24-40℃~+85℃ 1.1uA 16 2.3V~5.5V 3mA 400kHz 8 I2C、SMBus Interrupt Output Reset function、Cascade and address expansion TSSOP-24 I/O Expanders ROHSNXP SemiconductorsI/O ExpandersTPS562200DDC
UncategorisedTexas Instruments
BSS138
SOT-23-55℃~+150℃ 1 N-channel 1.1Ω@10V、1.2Ω@4.5V 1.2V 1.7nC@10V 17.5pF 340mA 350mW 50V 6.5pF N-Channel SOT-23 MOSFETs ROHShongjiachengMOSFETs
SS14
SMA(DO-214AC)-55℃~+150℃ 1A 25A 300uA@40V 40V 550mV@1A Independent SMA(DO-214AC) Schottky Diodes ROHSMDDSchottky DiodesSI2318CDS
SOT-23-55℃~+150℃ 1 N-channel 2.1W 2.5V 2.9nC@4.5V 30pF 340pF 40V 5.6A 51mΩ@4.5V 60pF N-Channel SOT-23 MOSFETs ROHSVishay IntertechnologyMOSFETs
Parts
201| Qty | Value | Footprint | References |
|---|---|---|---|
| 25 | 100n | Capacitor_SMD:C_0603_1608Metric | C1, C2, C10, C12, C13, C17, C18, C21, C23, C24, C25, C26, C29, C30, C31, C32 +9 |
| 14 | 300 | Resistor_SMD:R_0603_1608Metric | R2, R3, R35, R36, R38, R39, R44, R56, R58, R59, R60, R61, R64, R65 |
| 13 | 10k | Resistor_SMD:R_0603_1608Metric | R5, R11, R12, R17, R22, R33, R45, R46, R47, R48, R49, R50, R57 |
| 9 | 22u | Capacitor_SMD:C_0603_1608Metric | C19, C20, C22, C27, C28, C33, C35, C38, C39 |
| 7 | 1u | Capacitor_SMD:C_0603_1608Metric | C47, C52, C53, C54, C55, C56, C57 |
| 5 | 1k | Resistor_SMD:R_0603_1608Metric | R28, R31, R32, R52, R53 |
| 5 | Service | Button_Switch_SMD:SW_SPST_TL3305B | SW2, SW3, SW4, SW5, SW7 |
| 4 | 1.1k | Resistor_SMD:R_0603_1608Metric | R10, R15, R20, R25 |
| 4 | 10n | Capacitor_SMD:C_0603_1608Metric | C48, C49, C50, C51 |
| 4 | 16k | Resistor_SMD:R_0603_1608Metric | R7, R13, R18, R23 |
| 4 | 22nF | Capacitor_SMD:C_0603_1608Metric | C7, C8, C15, C16 |
| 4 | 49.9 | Resistor_SMD:R_0603_1608Metric | R40, R41, R42, R43 |
| 4 | 49.9k | Resistor_SMD:R_0603_1608Metric | R8, R14, R19, R24 |
| 4 | 680u | Capacitor_SMD:CP_Elec_8x10 | C3, C6, C11, C14 |
| 4 | BSS138 | Package_TO_SOT_SMD:SOT-23 | Q3, Q4, Q7, Q8 |
| 4 | DRV8874 | Package_SO:HTSSOP-16-1EP_4.4x5mm_P0.65mm_EP3.4x5mm_Mask3x3mm_ThermalVias | U2, U3, U4, U5 |
| 4 | SS14 | Diode_SMD:D_SMA | D3, D4, D5, D8 |
| 4 | TBD | Resistor_SMD:R_0603_1608Metric | R9, R16, R21, R26 |
| 3 | 470 | Resistor_SMD:R_0603_1608Metric | R51, R54, R55 |
| 3 | LED | LED_SMD:LED_0603_1608Metric | D1, D2, D6 |
| 3 | MountingHole | MountingHole:MountingHole_3.2mm_M3_Pad_Via | H1, H2, H3 |
| 2 | 10u | Capacitor_SMD:C_0603_1608Metric | C41, C43 |
| 2 | 18p | Capacitor_SMD:C_0603_1608Metric | C36, C37 |
| 2 | 220 | Resistor_SMD:R_0603_1608Metric | R29, R30 |
| 2 | BC817-40(SOT23) | Package_TO_SOT_SMD:SOT-23 | Q1, Q2 |
| 2 | Si2318CDS | Package_TO_SOT_SMD:SOT-23 | Q5, Q6 |
| 1 | 0 | Resistor_SMD:R_0603_1608Metric | R27 |
| 1 | 100 | Resistor_SMD:R_0603_1608Metric | R34 |
| 1 | 100k | Resistor_SMD:R_0603_1608Metric | R6 |
| 1 | 12V MAIN | MountingHole:MountingHole_3.2mm_M3_Pad_Via | H5 |
| 1 | 20Amp | Fuse:Fuseholder_Clip-6.3x32mm_Littelfuse_102_122_Inline_P34.21x7.62mm_D1.98mm_Horizontal | F1 |
| 1 | 21k | Resistor_SMD:R_0603_1608Metric | R1 |
| 1 | 25MHz YXC X322525MOB4SI | Crystal:Crystal_SMD_3225-4Pin_3.2x2.5mm | Y1 |
| 1 | 33k | Resistor_SMD:R_0603_1608Metric | R4 |
| 1 | 4.7µ | Inductor_SMD:L_Bourns-SRN4018 | L6 |
| 1 | 6k8 | Resistor_SMD:R_0603_1608Metric | R37 |
| 1 | 93LC46BT-E/OT | Package_TO_SOT_SMD:SOT-23-6 | U12 |
| 1 | A1 | LED_SMD:LED_0603_1608Metric | D12 |
| 1 | A2 | LED_SMD:LED_0603_1608Metric | D13 |
| 1 | ADDR | Jumper:SolderJumper-3_P1.3mm_Bridged12_RoundedPad1.0x1.5mm | JP9 |
| 1 | ATX-24 (Molex 39-28-1243) | Connector_Molex:Molex_Mini-Fit_Jr_5566-24A_2x12_P4.20mm_Vertical | J6 |
| 1 | ATX_VSB_OUT | Jumper:SolderJumper-2_P1.3mm_Open_TrianglePad1.0x1.5mm | JP7 |
| 1 | Amphenol 10053363-200LF | iotta_footprints_v6:Amphenol_10053363-200LF_WingTAT ER64BGFBK_Compatible_BOTTOM | J5 |
| 1 | B1 | LED_SMD:LED_0603_1608Metric | D14 |
| 1 | B2 | LED_SMD:LED_0603_1608Metric | D15 |
| 1 | CONSOLE | Connector_USB:USB_C_Receptacle_Palconn_UTC16-G | P2 |
| 1 | CP2102N-A01-GQFN24 | Package_DFN_QFN:QFN-24-1EP_4x4mm_P0.5mm_EP2.6x2.6mm | U11 |
| 1 | Control | TerminalBlock_Phoenix:TerminalBlock_Phoenix_PT-1,5-6-3.5-H_1x06_P3.50mm_Horizontal | J9 |
| 1 | DCDC_IN | Connector_PinHeader_2.54mm:PinHeader_1x01_P2.54mm_Vertical | J10 |
| 1 | DM9051 | Package_DFN_QFN:QFN-32-1EP_5x5mm_P0.5mm_EP3.3x3.3mm_ThermalVias | U13 |
| 1 | DRV1_PMODE | Jumper:SolderJumper-3_P1.3mm_Bridged12_RoundedPad1.0x1.5mm | JP4 |
| 1 | DRV2_PMODE | Jumper:SolderJumper-3_P1.3mm_Bridged12_RoundedPad1.0x1.5mm | JP1 |
| 1 | DRV3_PMODE | Jumper:SolderJumper-3_P1.3mm_Bridged12_RoundedPad1.0x1.5mm | JP3 |
| 1 | DRV4_PMODE | Jumper:SolderJumper-3_P1.3mm_Bridged12_RoundedPad1.0x1.5mm | JP2 |
| 1 | ESP32 USB | Connector_USB:USB_C_Receptacle_Palconn_UTC16-G | P1 |
| 1 | ESP32-S3-WROOM-1-N16R2 | PCM_Espressif:ESP32-S3-WROOM-1 | U8 |
| 1 | EXT IO | Connector_PinHeader_2.54mm:PinHeader_1x06_P2.54mm_Vertical | J16 |
| 1 | EXT1 | LED_SMD:LED_0603_1608Metric | D16 |
| 1 | EXT2 | LED_SMD:LED_0603_1608Metric | D17 |
| 1 | FB0805/600R/2A | Inductor_SMD:L_0805_2012Metric | L2 |
| 1 | GND | MountingHole:MountingHole_3.2mm_M3_Pad_Via | H4 |
| 1 | GND | TestPoint:TestPoint_Plated_Hole_D2.0mm | J13 |
| 1 | LIS3DH | Package_LGA:LGA-16_3x3mm_P0.5mm_LayoutBorder3x5y | U7 |
| 1 | MCP1703Ax-250xxTT | Package_TO_SOT_SMD:SOT-23 | U15 |
| 1 | Motor 1 | TerminalBlock_Phoenix:TerminalBlock_Phoenix_PT-1,5-5-3.5-H_1x05_P3.50mm_Horizontal | J2 |
| 1 | Motor 2 | TerminalBlock_Phoenix:TerminalBlock_Phoenix_PT-1,5-5-3.5-H_1x05_P3.50mm_Horizontal | J1 |
| 1 | Motor 3 | TerminalBlock_Phoenix:TerminalBlock_Phoenix_PT-1,5-5-3.5-H_1x05_P3.50mm_Horizontal | J4 |
| 1 | Motor 4 | TerminalBlock_Phoenix:TerminalBlock_Phoenix_PT-1,5-5-3.5-H_1x05_P3.50mm_Horizontal | J3 |
| 1 | OLED_128x64 | iotta_footprints:OLED_128x64_Module | DIS1 |
| 1 | PANEL BTN | Connector_PinHeader_2.54mm:PinHeader_1x06_P2.54mm_Vertical | J14 |
| 1 | PANEL LED | Connector_PinSocket_2.54mm:PinSocket_1x03_P2.54mm_Vertical | J8 |
| 1 | PCA9555PW | Package_SO:TSSOP-24_4.4x7.8mm_P0.65mm | U17 |
| 1 | PGM | Button_Switch_SMD:SW_SPST_B3U-1000P | SW1 |
| 1 | PMBUS_CL | Jumper:SolderJumper-2_P1.3mm_Open_TrianglePad1.0x1.5mm | JP6 |
| 1 | PMBUS_DA | Jumper:SolderJumper-2_P1.3mm_Open_TrianglePad1.0x1.5mm | JP5 |
| 1 | PSOK | LED_SMD:LED_0603_1608Metric | D7 |
| 1 | RJ45_Hanrun_HR911105A_Horizontal | Connector_RJ:RJ45_Hanrun_HR911105A_Horizontal | J7 |
| 1 | TMP112AIDRLR | Package_TO_SOT_SMD:SOT-563 | U10 |
| 1 | TPS562200 | Package_TO_SOT_SMD:SOT-23-6 | U9 |
| 1 | TSOP384xx | OptoDevice:Vishay_MINICAST-3Pin | U1 |
The 195 most common of 201 parts.
Questions
How big is the Linear window controller PCB?
It measures 114.3 × 86.4 mm and has 4 copper layers, 1.6 mm thick.
What parts does the Linear window controller use?
201 parts, built around the CP2102N-A01-GQFN24, ESP32-S3-WROOM-1-N16R2, DRV8874PWP and TMP112AIDRLR(UMW). The full list of its parts is on this page, with links to each part's symbol and footprint where PCBKit's library has them.
Where can I download the Linear window controller KiCad files?
From the eflukx/Linear-motor-window-controller repository on GitHub, at the commit this page was made from: the board is linear_window_controller.kicad_pcb and its schematic Schematics V1/linear_window_controller.kicad_sch. PCBKit opens the board in the browser, with nothing to install.
Can I use the Linear window controller design in my own project?
Its repository states no licence, so its author keeps all rights: ask eflukx before reusing the design.
Similar boards
- 4 layers99 × 99 mm
PrntrBoardV1
ghent360/PrntrBoard
3D Printer controller board using STM32 NUCLEO-F446 kit TMC2130/2660/2209 drivers
238 parts24 - 2 layers52 × 33 mm
Drone ESC Bridge
jerinabr/Drone_ESC_Bridge
PCB that allows the NVIDIA Jetson to communicate with the 4-in-1 ESC for the drone
24 parts - 2 layers148.7 × 104.3 mm
- 4 layers130 × 90 mm
LizardBot1 ControlBoard v1
lizard-electronics/LizardBot1_ProjectFiles
Project Files for LizardBot 1 differential-drive ROS2 robot.
202 parts1Apache-2.0 - 4 layers150.5 × 54.4 mm
Yed eye
caglarylmz/Personal-PCB-Projects
This repository includes my personal electronic design projects.
114 parts - 4 layers71.8 × 40.1 mm
- 2 layers90 × 100 mm
