6 layers21.4 × 32.3 mm
4 layers42.7 × 52 mm
HPM5E31
HNUST-Dust/HPM5E1HPM5E PCB
- Size
- 42.7 × 52 mm
- Copper layers
- 4
- Thickness
- 1.6 mm
- Parts
- 225
- Nets
- 257
- Pads
- 902
- Tracks, vias
- 2,154, 361
- Pours
- 29
- Routed
- Yes
- KiCad
- KiCad 10.0 (file 20260206)
- Created
- 14 Sep 2026
- Updated
- 18 Oct 2026
Overview
HPM5E31 is an open-source printed circuit board by HNUST-Dust, from the HNUST-Dust/HPM5E repository on GitHub. It is a 4-layer board of 42.7 × 52 mm with 225 parts on 257 nets, routed with 2,154 tracks and 361 vias.
It is built around the HPM5E31IGN1, TJA1042TK/3/1 and RTL8201F-VB-CG, with the RY3430, RY8411 and W25Q128JVSIQ among its other parts. Its parts include 79 capacitors, 53 resistors, 23 diodes, 18 fuses and 13 ICs.
Main components
12
HPM5E31IGN1
BGA-196(12x12)-40℃~+105℃ 148 16bit 1MB 32 Bit 3V~3.6V 480MHz 544KB Built-in+External FLASH Power-on reset (POR)、Undervoltage detection (BOR/LVD/LVR/LVI)、Watchdog reset、Software reset、External pin reset (NRST)、Built-in general-purpose timer、Hardware CRC RISC-V BGA-196(12x12) Microcontrollers (MCU/MPU/SOC) ROHSHPMICROMicrocontrollers (MCU/MPU/SOC)TJA1042TK/3/1
HVSON-8-EP(3x3)Low-power mode、Immunity optimization、Under-voltage lockout (UVLO)、Error detection and recovery HVSON-8-EP(3x3) Ethernet Transceivers ROHSNXP SemiconductorsEthernet Transceivers
RTL8201F-VB-CG
QFN-32-EP(5x5)0℃~+70℃ 1 10BASE-T、100BASE-TX 10Mbit/s、100Mbit/s 3.3V MII、RMII PHY Transceiver QFN-32-EP(5x5) Ethernet Transceivers ROHSRealtek SemiconEthernet Transceivers
RY3430
SOT-23-5-40℃~+85℃ 1 1.2MHz 2.5V~5.5V 3A 40uA Adjustable Buck Buck Built-in Yes SOT-23-5 DC-DC Converters ROHSRYCHIP Semiconductor Inc.DC-DC Converters
RY8411
SOT-23-6-40℃~+85℃@(TA) 1 1.2A 400uA 4V~38V 800kHz Adjustable Buck Buck Built-in Yes SOT-23-6 DC-DC Converters ROHSRYCHIP Semiconductor Inc.DC-DC Converters
W25Q128JVSIQ
SOIC-8-208mil-40℃~+85℃ 100,000 cycles 120ms@(32KB) 128Mbit 133MHz 1uA 2.7V~3.6V 20 Years 3ms Power-on reset、Hardware write protection、Software write protection、Write enable latch、Absolute write protection SPI SOIC-8-208mil NOR FLASH ROHSWinbondNOR FLASH
ICM-42688P-HXY
LGA-14(2.5x3)-40℃~+85℃ 1.71V~3.6V 16bit 4uA IMU (accelerometer + gyroscope) Motion event detection、Synchronization and timestamp、Support over-range detection SPI、I2C X,Y,Z X,Y,Z ±16g ±2000dps LGA-14(2.5x3) Accelerometers ROHSHXY MOSFETAccelerometersTJA1101BHN
QFN-36-EP(6x6)Undervoltage Protection、Built-in LDO QFN-36-EP(6x6) Power Over Ethernet (PoE) Controllers ROHSNXP SemiconductorsPower Over Ethernet (PoE) ControllersUSBLC6-2SC6
SOT-23-60.35pF、0.8pF 100nA 150W@8/20us 15V 2 5V 6A@8/20us 6V ESD SOT-23-6 ESD and Surge Protection (TVS/ESD) ROHSUMWESD And Surge Protection (TVS/ESD)
ESD9B5.0ST5G
SOD-923(0402)-55℃~+125℃ 1 10V 15pF 5V 8.4V 80W@8/20us 80nA 8A@8/20us Bidirectional ESD IEC 61000-4-2、IEC 61000-4-5 SOD-923(0402) ESD and Surge Protection (TVS/ESD) ROHSTECH PUBLICESD And Surge Protection (TVS/ESD)
BSMD0603-005-15V
0603-40℃~+85℃ 1.05mm 1.85mm 150mA 15V 1mm 1s 3.8Ω 30Ω 40A 500mW 50mA 0603 Resettable Fuses ROHSBHFUSEResettable Fuses
ACM201290Ω4A
SMD-4P,1.2x2.0x0.80PSMD-4P,1.2x2.0x0.80P New Arrivals ROHSTDKUncategorised
Parts
225| Qty | Value | Footprint | References |
|---|---|---|---|
| 52 | 100nF | Capacitor_SMD:C_0402_1005Metric | C1, C2, C3, C22, C23, C24, C25, C27, C29, C30, C31, C32, C100, C101, C102, C103 +36 |
| 28 | 10K | Resistor_SMD:R_0402_1005Metric | R10, R13, R22, R25, R26, R28, R30, R31, R32, R33, R34, R39, R43, R44, R45, R46 +12 |
| 10 | ESD9B5.0ST5G | Diode_SMD:D_SOD-923 | D11, D12, D13, D14, D16, D17, D18, D19, D29, D30 |
| 10 | SMD0402 | Fuse:Fuse_0402_1005Metric | F13, F14, F15, F16, F17, F18, F19, F20, F21, F22 |
| 8 | 4.7K | Resistor_SMD:R_0402_1005Metric | R15, R16, R20, R24, R36, R41, R61, RR1 |
| 8 | BSMD0603-005-15V | Fuse:Fuse_0603_1608Metric | F3, F4, F5, F6, F7, F8, F9, F10 |
| 5 | 10uF | Capacitor_SMD:C_0603_1608Metric | C6, C7, C18, C20, C42 |
| 5 | 4.7uF | Capacitor_SMD:C_0402_1005Metric | C33, C35, C44, C45, C47 |
| 4 | 10pF | Capacitor_SMD:C_0402_1005Metric | C78, C79, C82, C83 |
| 4 | 120 | Resistor_SMD:R_0402_1005Metric | R48, R49, R50, R51 |
| 4 | 22uF 10V | Capacitor_SMD:C_0805_2012Metric | C50, C51, C52, C53 |
| 4 | ACM2012(90欧) | Inductor_SMD:L_CommonModeChoke_Coilank_ACM3225 | L4, L5, L6, L7 |
| 4 | MountingHole_Pad_MP | MountingHole:MountingHole_2.2mm_M2_DIN965_Pad | H13, H14, H15, H16 |
| 4 | PESD1CAN | Package_TO_SOT_SMD:SOT-23-3 | D22, D23, D24, D25 |
| 4 | TJA1042TK-3 | Package_SON:HVSON-8-1EP_3x3mm_P0.65mm_EP1.6x2.4mm | U9, U10, U11, U12 |
| 4 | ~ | Connector_JST:JST_GH_BM02B-GHS-TBT_1x02-1MP_P1.25mm_Vertical | H6, H7, H8, H9 |
| 4 | ~ | Connector_JST:JST_GH_BM04B-GHS-TBT_1x04-1MP_P1.25mm_Vertical | H5, H10, H11, H12 |
| 3 | 10uF | Capacitor_SMD:C_0402_1005Metric | C21, C37, C39 |
| 3 | 330R | Resistor_SMD:R_0402_1005Metric | R37, R42, R62 |
| 2 | 12pF | Capacitor_SMD:C_0402_1005Metric | C40, C41 |
| 2 | 2012共模环 | Inductor_SMD:L_CommonModeChoke_Coilcraft_0805USB | L9, L10 |
| 2 | 22uF | Capacitor_SMD:C_0603_1608Metric | C26, C28 |
| 2 | 3416自耦环 | Inductor_SMD:L_CommonMode_Wurth_WE-CNSW-1206 | L8, L11 |
| 2 | 4.7uH | Inductor_SMD:L_APV_APH0420 | L1, L2 |
| 2 | LED_G | LED_SMD:LED_0402_1005Metric | D6, D8 |
| 2 | LOGO | LOGO | G***, G*** |
| 2 | ~ | Connector_JST:JST_GH_BM03B-GHS-TBT_1x03-1MP_P1.25mm_Vertical | H1, H2 |
| 1 | 100nF | Capacitor_SMD:C_0603_1608Metric | C49 |
| 1 | 10K | Resistor_SMD:R_0603_1608Metric | R2 |
| 1 | 10R | Resistor_SMD:R_0402_1005Metric | R18 |
| 1 | 1K | Resistor_SMD:R_0402_1005Metric | R29 |
| 1 | 1M | Resistor_SMD:R_0402_1005Metric | R12 |
| 1 | 2.49K | Resistor_SMD:R_0402_1005Metric | R57 |
| 1 | 2012共模环 | Inductor_SMD:L_CommonModeChoke_Coilcraft_1812CAN | L12 |
| 1 | 24M | Crystal:Crystal_SMD_2016-4Pin_2.0x1.6mm | Y1 |
| 1 | 270K | Resistor_SMD:R_0603_1608Metric | R14 |
| 1 | 33R | Resistor_SMD:R_0402_1005Metric | R38 |
| 1 | 36R | Resistor_SMD:R_1206_3216Metric | R40 |
| 1 | 4.7uH | Inductor_SMD:L_Wuerth_PMCI-252010 | L3 |
| 1 | 45K | Resistor_SMD:R_0603_1608Metric | R3 |
| 1 | 470nF | Capacitor_SMD:C_0402_1005Metric | C98 |
| 1 | 51K | Resistor_SMD:R_0603_1608Metric | R17 |
| 1 | AGM60P100A | Package_DFN_QFN:PQFN-8-EP_6x5mm_P1.27mm_Generic | Q1 |
| 1 | AO3404A | Package_TO_SOT_SMD:SOT-23 | Q4 |
| 1 | BZT52C12S WH | Diode_SMD:D_SOD-323 | D2 |
| 1 | Blue | LED_SMD:LED_0603_1608Metric | D3 |
| 1 | HPM5E31IGN1 | Library:BGA-196_14x14_12.0x12.0mm_P0.8mm | U14 |
| 1 | ICM-42688P-HXY | Package_LGA:LGA-14_3x2.5mm_P0.5mm_LayoutBorder3x4y | U8 |
| 1 | LED_E | LED_SMD:LED_0402_1005Metric | D7 |
| 1 | PH2.0 | Connector_JST:JST_GH_BM02B-GHS-TBT_1x02-1MP_P1.25mm_Vertical | H4 |
| 1 | PH2.0 | Connector_JST:JST_GH_BM04B-GHS-TBT_1x04-1MP_P1.25mm_Vertical | H3 |
| 1 | PMBT3904 | Package_TO_SOT_SMD:SOT-23 | Q3 |
| 1 | PMBT3904 | Package_TO_SOT_SMD:SOT-23-3 | Q2 |
| 1 | RTL8201F-VB-CG | kicad_api_lib:RTL8201F-VB-CG | U3 |
| 1 | RY3430 | Package_TO_SOT_SMD:SOT-23-5 | U4 |
| 1 | RY8411 | Package_TO_SOT_SMD:SOT-23-6 | U5 |
| 1 | SD103AWS | Diode_SMD:D_SOD-323 | D9 |
| 1 | SD103AWS S4 | Diode_SMD:D_SOD-323 | D10 |
| 1 | SMBJ30A | Diode_SMD:D_SMA | D1 |
| 1 | TJA1101B | Package_DFN_QFN:QFN-36-1EP_6x6mm_P0.5mm_EP4.1x4.1mm | U2 |
| 1 | USBLC6-2SC6 | Package_TO_SOT_SMD:SOT-23-6 | U6 |
| 1 | USB_C_Receptacle_USB2.0_16P | Connector_USB:USB_C_Receptacle_GCT_USB4105-xx-A_16P_TopMnt_Horizontal | J1 |
| 1 | W25Q128JVS | Package_SO:SOIC-8_5.3x5.3mm_P1.27mm | U7 |
| 1 | WS2812B | LED_SMD:LED_WS2812B-Mini_PLCC4_3.5x3.5mm | D15 |
| 1 | ~ | Connector_JST:JST_SH_BM10B-SRSS-TB_1x10-1MP_P1.00mm_Vertical | U1 |
| 1 | ~ | Library:BUZ-SMD_L5.0-W5.5-P4.60 | MLT-1 |
| 1 | ~ | Connector_AMASS:AMASS_XT30U-M_1x02_P5.0mm_Vertical | XT1 |
| 1 | 笑脸开关3*5 | Button_Switch_SMD:SW_Push_1P1T-MP_NO_Horizontal_Alps_SKRTLAE010 | KEY1 |
Similar boards
- 2 layers50 × 50 mm
- 4 layers87.6 × 50.8 mm
100base t1-converter
ehntoo/100base-t1-converter
This project provides a media converter for connecting 100Base-TX ethernet to 100Base-T1 (Automotive Ethernet) networks, using an NXP TJA1101 PHY.
83 parts16 - 4 layers75.9 × 25 mm
100base T1-100base TX Media Converter
tomy983/100base-T1-100base-TX-Media-Converter
PCB designet to convert automotive ethernet 100base-T1 to 100base-TX ethernet
70 parts2MIT - 4 layers80 × 50 mm
MianCtrl H7
Aiyin4Da-2/Main_Ctrl_H7
STM32H723VGT6 MainCtrlBoard Author: Aiyin4DaGLD · Hardware: v1.2 · Updated: 2026-08-21
153 partsMIT - 2 layers121.5 × 136.5 mm
- 2 layers56.8 × 22.8 mm
- 2 layers194 × 129.5 mm
Questions
How big is the HPM5E31 PCB?
It measures 42.7 × 52 mm and has 4 copper layers, 1.6 mm thick.
What parts does the HPM5E31 use?
225 parts, built around the HPM5E31IGN1, TJA1042TK/3/1, RTL8201F-VB-CG and RY3430. The full list of its parts is on this page, with links to each part's symbol and footprint where PCBKit's library has them.
Where can I download the HPM5E31 KiCad files?
From the HNUST-Dust/HPM5E repository on GitHub, at the commit this page was made from: the board is hardware/HPM5E31.kicad_pcb and its schematic hardware/HPM5E31.kicad_sch. PCBKit opens the board in the browser, with nothing to install.
Can I use the HPM5E31 design in my own project?
Its repository states no licence, so its author keeps all rights: ask HNUST-Dust before reusing the design.